Trucks, Trains, Ships and Planes

Posted by PITHOCRATES - August 21st, 2013

Technology 101

Big Over-the-Road Tractor Trailer Trucks have Big Wheels so they can have Big Brakes

If you buy a big boat chances are you have a truck or a big SUV to pull it.  For rarely do you see a small car pulling a large boat.  Have you ever wondered why?  A small car can easily pull a large boat on a level (or a near level) surface.  That’s not the problem.  The problem is stopping once it gets moving.  For that is a lot of mass.  Creating a lot of kinetic energy (one half of the mass times velocity squared).  Which is dissipated as heat as brake shoes or pads rub against the wheels.  This is why you need a big truck or SUV to pull a boat.  So you can stop it once it gets moving.

Big trucks and big SUVs have big wheels and big brakes.  Large areas where brake pads/shoes press against a rotating wheel.  All of which is heavy duty equipment.  That can grab onto to those wheels and slow them down.  Converting that kinetic energy into heat.  This is why the big over-the-road tractor trailer trucks have big wheels.  So they can have big enough brakes to stop that huge mass once it gets moving.  Without the brakes turning white hot and melting.  Properly equipped trucks can carry great loads.  Moving freight safely across our highways and byways.  But there is a limit to what they can carry.  Too much weight spread between too few axles will pound the road apart.  Which is why the state police weighs our trucks.  To make sure they have enough axles supporting the load they’re carrying.  So they don’t break up our roads.  And that they can safely stop.

It’s a little different with trains.  All train cars have a fixed number of axles.  But you will notice the size of the cars differ.  Big oversized boxcars carry a lot of freight.  But it’s more big than heavy.  Heavy freight, on the other hand, like coal, you will see in smaller cars.  So the weight they carry doesn’t exceed the permissible weight/axle.  If you ever sat at a railroad crossing as a train passed you’ve probably noticed that the rail moves as the train travels across.  Watch a section of rail the next time you’re stopped by a train.  And you will see the rail sink a little beneath the axle as it passes over.

If a Ship is Watertight and Properly Balanced it can be covered in Green Water and Rise back to the Surface

So the various sizes of train cars (i.e., rolling stock) keeps each car from being overloaded.  Unlike a truck.  Steel haulers and gravel trains (i.e., dump trucks) have numerous axles beneath the load they’re carrying.  But these axles are retractable.  For the more wheels in contact with the road the more fuel is needed to overcome the friction between the tires and the road.  And the more tires in contact with the road the more tire wear there is.  Tires and fuel are expensive.  So truckers like to have as few tires in contact with the road as possible.  When they’re running empty they will have as many of these wheels retracted up as possible.  Something you can’t do with a train.

That said, a train’s weight is critical for the safe operation of a train.  In particular, stopping a train.  The longer a train is the more distance it takes to stop.  It is hard to overload a particular car in the string of cars (i.e., consist) but the total weight tells engineers how fast they can go.  How much they must slow down for curves.  How much distance they need to bring a train to a stop.  And how many handbrakes to set to keep the train from rolling away after the pressure bleeds out of the train line (i.e., the air brakes).  You do this right and it’s safe sailing over the rails.  Ships, on the other hand, have other concerns when it comes to weight.

Ships float.  Because of buoyancy.  The weight of the load presses down on the water while the surface of the water presses back against the ship.  But where you place that weight in a ship makes a big difference.  For a ship needs to maintain a certain amount of freeboard.  The distance between the surface of the water and the deck.  Waves toss ships up and down.  At best you just want water spray splashing onto your deck.  At worst you get solid water (i.e., green water).  If a ship is watertight and properly balanced it can be covered in green water and rise back to the surface.  But if a ship is loaded improperly and lists to one side or is low in the bow it reduces freeboard.  Increases green water.  And makes it less likely to be able to safely weather bad seas.  The SS Edmund Fitzgerald sank in 1975 while crossing Lake Superior in one of the worst storms ever.  She was taking on water.  Increasing her weight and lowering her into the water.  Losing freeboard.  Had increasing amounts of green water across her deck.  To the point that a couple of monster waves crashed over her and submerged her and she never returned to the surface.  It happened so fast that the crew was unable to give out a distress signal.  And as she disappeared below the surface her engine was still turning the propeller.  Driving her into the bottom of the lake.  Breaking the ship in two.  And the torque of the spinning propeller twisting the stern upside down.

Airplanes are the only Mode of Transportation that has two Systems to Carry their Load

One of the worst maritime disasters on the Great Lakes was the sinking of the SS Eastland.  Resulting in the largest loss of life in a shipwreck on the Great Lakes.  In total 844 passengers and crew died.  Was this in a storm like the SS Edmund Fitzgerald?  No.  The SS Eastland was tied to the dock on the Chicago River.  The passengers all went over to one side of the ship.  And the mass of people on one side of the ship caused the ship to capsize.  While tied to the dock.  On the Chicago River.  Because of this shift in weight.  Which can have catastrophic results.  As it can on airplanes.  There’s a sad YouTube video of a cargo 747 taking off.  You then see the nose go up and the plane fall out of the sky.  Probably because the weight slid backwards in the plane.  Shifting the center of gravity.  Causing the nose of the plane to pitch up.  Which disrupted the airflow over the wings.  Causing them to stall.  And with no lift the plane just fell out of the sky.

Airplanes are unique in one way.  They are the only mode of transportation that has two systems to carry their weight.  On the ground the landing gear carries the load.  In the air the wings carry the load.  Which makes taking off and landing the most dangerous parts of flying.  Because a plane has to accelerate rapidly down the runway so the wings begin producing lift.  Once they do the weight of the aircraft begins to transfer from the landing gear to the wings.  Allowing greater speeds.  However, if something goes wrong that interferes with the wings producing lift the wings will be unable to carry the weight of the plane.  And it will fall out of the sky.  Back onto the landing gear.  But once the plane leaves the runway there is nothing the landing gear can gently settle on.  And with no altitude to turn or to glide back to a runway the plane will fall out of the sky wherever it is.  Often with catastrophic results.

A plane has a lot of mass.  And a lot of velocity.  Giving it great kinetic energy.  It takes long runways to travel fast enough to transfer the weight of the aircraft from the landing gear to the wings.  And it takes a long, shallow approach to land an airplane.  So the wheels touch down gently while slowly picking up the weight of the aircraft as the wings lose lift.  And it takes a long runway to slow the plane down to a stop.  Using reverse thrusters to convert that kinetic energy into heat.  Sometimes even running out of runway before bringing the plane to a stop.  No other mode of transportation has this additional complication of travelling.  Transferring the weight from one system to another.  The most dangerous part of flying.  Yet despite this very dangerous transformation flying is the safest mode of traveling.  Because the majority of flying is up in the air in miles of emptiness.  Where if something happens a skilled pilot has time to regain control of the aircraft.  And bring it down safely.

www.PITHOCRATES.com

Share

Tags: , , , , , , , , , , , , , , , , , , , , , ,

Environmental Policies create Chicken Wing Shortage this Super Bowl Sunday

Posted by PITHOCRATES - January 26th, 2013

Week in Review

There’s already been a lot of disappointment for football fans.  Especially for people in New England and Atlanta.  As well as for people in Denver, Houston, Seattle and Green Bay.  Whose teams came so close to making it to the Super Bowl that they could taste it.  And as if that disappointment wasn’t bad enough there’s something else they may not be able to taste (see Chicken wing shortage threatens Super Bowl Sunday by FOX NEWS posted on the New York Post).

The National Chicken Council released a report that said the demand for wings this year is at “an all-time high” due to decreased wing production caused by the high cost of corn and feed prices. Wings are currently the highest priced portion of a chicken and cost $2.11 a pound in the Northeast, up 12 percent from last year…

“Chicken companies produced about 1 percent fewer birds last year, due in large part to record high corn and feed prices,” Bill Roenigk, chief economist and market analyst at the Washington, D.C.-based National Chicken Council said in a release. “Corn makes up more than two-thirds of chicken feed and corn prices hit an all-time high in 2012, due to two reasons: last summer’s drought and pressure from a federal government requirement that mandates 40 percent of our corn crop be turned into fuel in the form of ethanol. Simply put, less corn equals higher feed costs, which means fewer birds produced.”

The Left claimed their environmental requirement to burn 40% of the corn crop as fuel in our cars had nothing to do with the higher food costs that have hurt families this past year.  But they did.  For corn is everywhere in our food supply.  We eat it as popcorn.  Corn on the cob.  Cream style corn.  And we eat the things that eat corn.  Or come from things that eat corn.  Chicken.  Beef.  Pork.  Milk.  Eggs.  Cheese.  Everything a family struggles to put on the kitchen table to feed their family.  All made more costly thanks to those environmental policies.  Policies based on rising temperature in the Nineties that didn’t continue to rise.  Proving all of their projections wrong.  Yet here we are.  Having to cut back on wings this Super Bowl Sunday.  Just so Al Gore can live in a mansion on the beach.  For even Al Gore doesn’t believe the global warming alarmism he puts out.  For if the sea levels were really rising he would not have bought a mansion on the beach.

If you can afford a mansion on the beach do you know what else you can afford?  All the chicken wings you heart desires.  So, if you want a good time this Super Bowl Sunday try to get an invite to the party Al Gore will be having in his mansion on the beach.  It should be a swinging time.

www.PITHOCRATES.com

Share

Tags: , , , , , , , , , , , , , ,